Generac-power-systems 1.6L 18 kW Instrukcja Użytkownika

STANDBY GENERATOROWNER'S MANUALThis manual should remain with the unit.A new standard of reliabilitySerial Number1.6L18 kWModelsNot intended fo

SPECIFICATIONSGENERATORType ... SynchronousRotor Insulation ...

COLD WEATHER KITFor cold climates, optional cold weather kit (part number 0F6148) is recommended. The kit includes:• Battery Warmer• 4” Junction Box

GENERATOR AC LEAD CONNECTIONSSee “Voltage Codes”. This generator may be rated at any one of three voltages, either single-phase or three-phase. The el

INSTALLATIONRefer to the separate “Installation Guide” supplied with the unit.PREPARATION BEFORE START-UPThe instructions in this section assume that

• Battery charger connection to 120 VAC.• Communication wires connected between transfer switch and generator (HTS only).• Unit secured to pad.STAR

GENERATOR CONTROL AND OPERATIONRefer to the appropriate control panel operator’s manual for this unit.OPERATING UNIT WITH MANUAL TRANSFER SWITCHIf the

MAINTENANCE PERFORMED BY SERVICE FACILITIES  Before working on the generator, ensure the fol-lowing:The AUTO/OFF/MANUAL switch is in the OFF positio

Figure 10.1 - Oil Dipstick and Oil Fill CapOIL FILL CAPOILDIPSTICKBATTERY FLUIDCheck battery electrolyte fluid based on the Maintenance Schedule. Flui

CHANGING ENGINE OILRefer to maintenance performed by service facilities for engine oil and filter change frequencies.Drain the oil while the engine is

MISCELLANEOUS MAINTENANCECLEANING THE GENERATORKeep the generator as clean and as dry as possible. Dirt and moisture that accumulates on internal gen-

Standby Generator SetsTable of ContentsSECTION PAGESAFETY RULES ... 1-1INTRODUCTION ...

SERVICE SCHEDULEThe following is a recommended maintenance schedule for small standby and residential generator sets. The established intervals in the

Maintenance Level 1 Level 2 Level 3 Level 4 Tasks Recom- Task Required Task Required Task Task mended Comp. to be done Comp. to be

Maintenance Level 1 Level 2 Level 3 Level 4 Tasks Recom- Task Required Task Required Task Task mended Comp. to be done Comp. to be

TROUBLESHOOTING GUIDEPROBLEM CAUSE CORRECTIONEngine won’t crank. 1. 15 amp fuse blown. 1. Replace fuse. 2. Loose or corroded or defective 2.

Standby Generator SetsNotes

Standby Generator SetsNotes

Standby Generator SetsNotes

Standby Generator SetsNotes

1 0G4827 1 ASSY RTR 104 KD1 HI EFF (18KW) 0G2927 1 RTR-102-20.0AD1 CPL (2006) (20KW) 0G2827 1 ASSY RTR 25KW 2P (2006) (25KW) 0G3451C 1

Study these SAFETY RULES carefully before install-ing, operating or servicing this equipment. Become familiar with this Owner’s Manual and with the un

1 N/A N/A UL BREAKER BQ2 A 0D5543 1 CB 0090A 2P 240V S BQ2 LL 0D5544 1 CB 0100A 2P 240V S BQ2 LL 0A2077 1 CB 0125A 2P 240V S BQ2 LL B

COMPONENTS INCLUDED IN 0G4578E 1 0F1823A 1 ENCL HSB CONTROL PANEL 2 0F3078 1 COVER CONTROL PANEL 3 0F2606 1 HINGE CONTINUOUS H-PANEL 4 036

1 0G3418 1 RADIATOR SUPPORT LH SIDE 1.6L 2 0G3421 1 VENTURI 1.6L 3 0G3419 1 RADIATOR SUPPORT RH SIDE 1.6L 4 0E9837B 1 RADIATOR 1.6L CHY 5

1 0G3343 1 MOUNTING BASE 1.6L 2007 C1 2 027482 2 WASHER SHAKEPROOF EXT 5/16 STL 3 070936 2 DAMPENER VIBRATION 4 070936C 2 VIB. ISO. 70-

1 0F3408C 1 BATTERY TRAY, C1 & C2 2 0F3411 1 STRAP BATTERY RETAINMENT 3 025507 1 WASHER SHAKEPROOF EXT 7/16 STL 4 059980 1 SCREW HHC M

• Before performing any maintenance on the gen-erator, disconnect its battery cables to prevent accidental start-up. Disconnect the cable from the bat

1 0G0207 REF ENGINE GENERAC 1.6L NG 2 0G0834 1 ENGINE PLATE 1.6L 3 0G0820 REF HOUSING BLOWER MACHINED 1.6L 4 0E9747 1 STARTER 12 VOLT 5 0

1 098290 1 ASM MOTOR STEPPER 2 098941A 1 HOUSING GOVERNOR CONNECTOR 3 098958A REF CONNECTOR INTERFACE ASSEMBLY 4 098942A 1 COVER CONNECTOR

1 026812 2 ELBOW 90D 3/4 NPT 2 075580 1 FLANGE FUEL INLET 3 0G1397A 1 FUEL REG. REWORK 1.6L 3600 '07 (3600RPM) 0G1397B 1 FUEL REG. REWO

(1) 1 0G3337 1 ROOF 1.6L C1 (1) 2 0G3336 1 REAR INTAKE WRAP 1.6L C1 (2) 3 077992 16 NUT HEX LOCK M6-1.0 SS NY INS (1) 4 0G3341 2 RIGHT S

1 0F7366 1 MUFFLER C1 2 0F7647 1 MUFFLER SADDLE 3 0F8095 1 PIPE EXHAUST OUTLET 4 0G3576 1 EXHAUST PIPE LOWER 1.6L 5 0E3257 4 SCREW HW

1-3INTRODUCTIONThank you for purchasing this model of the standby generator set product line.Every effort was expended to make sure that the informati

IDENTIFICATION RECORDDATA LABELEvery generator set has a DATA LABEL that contains important information pertinent to the generator. The data label, wh

BackPg001 Rev. A 04/07

EQUIPMENT DESCRIPTIONThis equipment is a revolving field, alternating cur-rent generator set. It is powered by a gaseous fueled engine operating at 18

ENGINE PROTECTIVE DEVICESThe standby generator may be required to operate for long periods of time without an operator on hand to monitor such engine

FUEL SYSTEMFUEL REQUIREMENTSThe standby generator may be equipped with one of the following fuel systems:• Natural gas fuel system• Propane vapor (P